Enjoy 5% OFF at VEVOR Canada! and Support Canadian Poncho at the Same Time!
Members Login
Username 
 
Password 
    Remember Me  
Canadian Poncho Homepage -> Canadian Poncho -> General 58-64 Full Size Forum -> I Need To Empty My Gas Tank ... UPDATE
Post Info TOPIC: I Need To Empty My Gas Tank ... UPDATE
Pontiacanada


A Poncho Legend!

Status: Offline
Posts: 20744
Date:
I Need To Empty My Gas Tank ... UPDATE
Permalink  

I have a 1/3 of a tank of old gas and I want it gone.
Driving the car until it is empty is not an option ... it's currently up on jackstands.
I don't want to idle/rev it for 40 hours!biggrin
I installed a new gas tank last November. This gas tank must have some kind of baffle/screen or something about a foot & a half down the filler tube. I tried putting a 1/2" hose connected to a vacuum pump down the tube about 20 times today and it hits a "wall", therefore I can't siphon it. When I pull the hose out, its not even wet.
There is no drain****.
I don't want to drop the tank, unless I have to.
Does anyone have any suggestions on how to drain it?

Thanks, Darryl.



-- Edited by Pontiacanada on Tuesday 5th of October 2010 06:43:41 PM

__________________

Prince Edward Island

'64 Parisienne CS "barn find" - last on the road in '86 ... Owner Protection Plan booklet, original paint, original near-mint aqua interior, original aqua GM floor mats, original 283, factory posi, and original rust.

67Poncho


Uber Guru

Status: Offline
Posts: 3677
Date:
RE: I Need To Empty My Gas Tank ...
Permalink  

When I was a teen and needed gas for my mini bike, I would remover the fuel line from the carb on Moms car, stick it into a javex bottle and the start the car and let it run filling up my little bottle. Usually got a gallon before the carb ran out of fuel!!!

 You can try the siphon trick as well on the fuel line but am not sure how it would work. Other than than, an electric fuel pump before her own fuel pump and let her go!!!

__________________

Vincent Jr.
Nov 18 to Dec 2 Black Friday UP TO 50% OFF Plus Huge Coupons
Nov 18 to Dec 2 Black Friday UP TO 50% OFF Plus Huge Coupons
JetFan


Guru

Status: Offline
Posts: 788
Date:
Permalink  

67Poncho wrote:

When I was a teen and needed gas for my mini bike, I would remover the fuel line from the carb on Moms car, stick it into a javex bottle and the start the car and let it run filling up my little bottle. Usually got a gallon before the carb ran out of fuel!!!

 You can try the siphon trick as well on the fuel line but am not sure how it would work. Other than than, an electric fuel pump before her own fuel pump and let her go!!!


Cheeky little buggar.  (This site is invaluable for moms with teenage sons!)  laughing.gif

 



__________________

GTO's are better than jewellery.
4SPEED427


A Poncho Legend!

Status: Offline
Posts: 50204
Date:
Permalink  

Do you have a way to put a couple of pounds of air pressure in the tank? If so, do that and catch it at the hose that is on the fuel pump inlet. That is how we used to do it in the shop,

__________________

1966 Strato Chief 2 door, 427 4 speed, 45,000 original miles 

1966 Grande Parisienne, 396 1 of 23 factory air cars (now converted to a "factory" 4 speed)
67Poncho


Uber Guru

Status: Offline
Posts: 3677
Date:
Permalink  

JetFan wrote:

67Poncho wrote:

When I was a teen and needed gas for my mini bike, I would remover the fuel line from the carb on Moms car, stick it into a javex bottle and the start the car and let it run filling up my little bottle. Usually got a gallon before the carb ran out of fuel!!!

 You can try the siphon trick as well on the fuel line but am not sure how it would work. Other than than, an electric fuel pump before her own fuel pump and let her go!!!


Cheeky little buggar.  (This site is invaluable for moms with teenage sons!)  laughing.gif

 


(lol) Mom and Dad knew what I did.... They weren't always happy when I took it to the extreme though!!! But with todays cars with EFI, unless you have a fuel pressure gauge or the talent to disconnect the fuel lines and then power up the fuel pump, it will be a lot tougher unless, you still have a car with a carb!!!

 



__________________

Vincent Jr.
jmont64


Canadian Poncho Superstar!

Status: Offline
Posts: 6749
Date:
Permalink  

Just hook it up to a big block for about 10 minutes, that should take care of it.

__________________
Jerel
427carl


A Poncho Legend!

Status: Offline
Posts: 35601
Date:
Permalink  

Just try a BBQ lighter and see if it will burn off the fumes..

__________________

 
Nov 18 to Dec 2 Black Friday UP TO 50% OFF Plus Huge Coupons
Nov 18 to Dec 2 Black Friday UP TO 50% OFF Plus Huge Coupons
rabbit64cs


Canadian Poncho Superstar!

Status: Offline
Posts: 7183
Date:
Permalink  

I do like the above ( Vincent ) , except I have a 1 litre bottle with a hose and fuel hard line attached to it. I fill the bottle and hang it from the hood attached to the carb , this gravity bottle feeds the carb. I run the unhooked pressure side of the fuel pump into a jerry can to catch the rotten fuel.

Nice thing with this is, I add fresh fuel to the tank once it's pumped down, slosh it around a bunch and repeat pumping till empty again. gets the tank pretty clean if they aren't too bad.

this beats changing fuel filters and emptying the float bowl....

__________________

later...rog

AADD supporting member !!
I'm a collector...not a builder!!Located in sunny central Saskatchewan at the lakehead!
ZigZag


Addicted!

Status: Offline
Posts: 144
Date:
Permalink  

Is the car entirely up on jack stands?  If so, I have a suggestion that worked for me:
  • Remove the gas line at fuel pump.
  • Put the fuel line into (or over) a shallow container. I used an oil catch pan.
  • Take out the jack stands holding up the front of the car (so the nose is down).
  • Remove the gas cap on the tank.
I didn't even need to suck on the hose to get it flowing. Gravity eventually did it's job and pushed the gas through the path of least resistance. You may not have to remove the cap if your tank is new and your vents are good, but it helps with the flow.

I'd have another catch pan handy to swap out if the other fills up, as well as something to stop the flow of fuel.  My fuel line was rubber, so I found a bolt big enough to plug it.

However you go about it, good luck.  Just don't be smoking while you do it, or dump the gas down the sewer (if you're in the city). biggrin

__________________

My 64 Safari build
67rag396


Poncho Master!

Status: Offline
Posts: 1282
Date:
Permalink  

Attach hoist to front of car, lift it up high enough and it will pour back out the filler.rofl.gifrofl.gif

__________________

1967 Parisienne 2+2
1967 Grande Parisienne

1967 Laurentian
1967 Strato Chief


Remember, "The Government" only has money confiscated from us.

 

 
Pontiacanada


A Poncho Legend!

Status: Offline
Posts: 20744
Date:
RE: I Need To Empty My Gas Tank ... UPDATE
Permalink  

Purchased one of these:

http://www.hotrodautosupply.com/eshop/index.php?_a=viewProd&productId=55

It should empty the tank. I'll connect it to the tank sending unit.
Hotrod Auto Supply located in good old Sask.



__________________

Prince Edward Island

'64 Parisienne CS "barn find" - last on the road in '86 ... Owner Protection Plan booklet, original paint, original near-mint aqua interior, original aqua GM floor mats, original 283, factory posi, and original rust.

sixtywagon


Uber Guru

Status: Offline
Posts: 3463
Date:
Permalink  

When I emptied my tank, I took the hose going to the carb off, and used a jerry can and turned the car over til no more gas came out. Also done it using compressed air into the filler, with rags stuffed around to seal, and unhooked the hose before the fuel pump, it forces the gas thru the lines and out the hose.

__________________

1960 Pontiac Strato Chief Safari
1960 Laurentian Safari 
1960 Laurentian 4door(scrapped)
2001 Grand Am Traded on a '96 Suburban 2WD
2002 Hyundai Accent(SOLD)
1968 Grand Parisienne Scrapped and SOLD

 

Calgary, Alberta, but raised in Peterborough
Page 1 of 1  sorted by
 
Quick Reply

Please log in to post quick replies.
Canadian Poncho Homepage -> Canadian Poncho -> General 58-64 Full Size Forum -> I Need To Empty My Gas Tank ... UPDATE
Tweet this page Post to Digg Post to Del.icio.us
.
Support Canadian Poncho!
Select Amount:
<
.
.
.